澳门威尼娱人网站-澳门威廉斯人8040-首页

?
欢迎来到导轨式升降机平台生产厂家

网站导航 | 设为首页 | 联系大家 | 导轨式升降机超级爬虫

专注 升降作业平台 生产与服务

为您提供更安全、质量、低成本 的升降作业平台

服务热线: 18866889959 18866889959

    企业资讯/PRODUCT

    联系 升降机-升降平台-专业定制升降机/货梯-澳门威尼娱人网站-澳门威廉斯人8040-首页

    18866889959

    企业资讯

    升降机操作技术和操作过程中的安全注意事项

    未知 浏览: 发布日期:2019-12-05 18:39
     升降机操作技术和操作过程中的安全注意事项:a.关闭地面电源的单独电源开关,关门,关闭上吊笼中的三相开关,然后按下所需方向的按钮启动电梯(操纵杆类型应把操纵杆推到所需方向位置并保持在该位置)。按钮开关按下“零”位置电梯停止(释放杠杆式手自动停止)。有限碰撞板不允许在电梯顶部和底部自动停止。b对于变速电梯,停止前将开关转到低速档。每班电梯第一次运行时,必须从最低楼层行驶,严禁从上到下行驶。当吊笼高出地面1~2m时,停下来测试制动性能。如有异常,应及时修理后方可使用。d.当人和货物装在车上时,载荷应均匀分布,以防超重;乘客空载时严禁超载运行,额定负载不得超过每吨12人;汽车顶部不允许有人或有货物(安装除外)。电梯应配备可靠的通讯装置,与指令紧密相连,并按信号操作。开车前,操作员必须按铃并鸣响警铃。电梯停在高处或地面电源开关未切断前,操作人员不得离开操作岗位。严禁无证开动机器。f、运行中发现电梯机械状况异常时,应马上停机,并采取有效措施将梯笼安装到底层。只有排除故障后,电梯才能继续运行。当运行中发现电气失控时,应马上按下紧急停止按钮。在故障排除之前,不得打开紧急停止按钮。维护应由专业人员进行,不允许未经授权的维护。如果临时维护不好,试着让人们先下车(通过车顶天窗入口爬上脚手架或地板)。电梯运行时不允许打开车门,乘客也不要靠在车门上。当电梯运行到顶部和底部时,禁止使用行程限位开关作为控制开关停止运行。

      Lift operation technology and safety precautions during operation:a.Turn off the separate power switch for ground power,close the door,turn off the three-phase switch in the upper cage,and then press the button in the desired direction to start the elevator(the type of joystick should be operated Push the lever to the desired directional position and keep it there).Elevator stops when the button switch is pressed to the"zero"position(release lever-type hand stops automatically).Limited collision plates do not allow automatic stops at the top and bottom of the elevator.b For variable-speed elevators,turn the switch to the low-speed position before stopping.When the elevator runs for the first time,each elevator must travel from the lowest floor,and it is strictly forbidden to travel from top to bottom.When the cage is 1-2m above the ground,stop to test the braking performance.If it is abnormal,it should be repaired before use.d.When people and goods are loaded on the car,the load should be evenly distributed to prevent overweight.Passengers are strictly prohibited from overloading when no-load,and the rated load cannot exceed 12 people per ton.No one or cargo is allowed on the top of the car(except for installation).The elevator should be equipped with reliable communication devices,closely connected to the instructions,and operated according to signals.Before driving,the operator must ring the bell and sound the alarm.The operator shall not leave the operation post until the elevator stops at a high place or the ground power switch is not cut off.Never operate the machine without a license.f.When the elevator machinery is found to be abnormal during operation,it should immediately stop and take effective measures to install the elevator cage on the ground floor.Only after the fault is eliminated can the elevator continue to run.When electrical runaway is found during operation,immediately press the emergency stop button.Do not turn on the emergency stop button until troubleshooting is complete.Maintenance should be performed by qualified personnel.Unauthorized maintenance is not allowed.If temporary maintenance is not good,try to get people out of the car first(climb up the scaffolding or floor through the roof sunroof entrance).The elevator is not allowed to open the doors while the elevator is running,and passengers should not lean on the doors.When the elevator runs to the top and bottom,it is prohibited to stop using the stroke limit switch as a control switch.

     
      (8)当人们可以在吊笼中搬运货物时,载荷应均匀分布,以防止超重。严禁超载运行。严禁人货混装。乘客不得超过产品说明中的规定。
     
      (9)遇大雨、大雾、六级及以上大风、导轨架及电缆结冰时,必须马上停止作业,将梯笼降至底层,打开制动器切断电源。暴风雨后,应对电梯的电路、各种安全装置和架体的连接进行全面检查。如发现问题,应及时维修加固,确认正常后方可运行。
     
      (10)当有许多人在工作时,应该有专门的人员在地面上维持秩序。
     
      (11)对于变速电梯,在停止电梯之前,将开关转到低速档。
     
      (12)作业后,将轿厢(梯笼)降至底层,将各操纵器(开关)转到零位,依次切断电源,锁好电源箱,锁好轿厢和外壳门,做好清洗和维护工作。(13)填写机队工作日志和交接班记录。
     
      (14)严格实行施工电梯的定期检查和维护制度。
    山东液压机械有限企业
    ??全国统一服务热线:18866889959
    ?? 固话:18866889959
    ?? 企业邮箱:18866889959
    ??企业网址:
    ??地址:山东省济南市济阳区济北街道泰兴东街8-1号院内A区
    Copyright © 2002-2019 澳门威尼娱人网站-澳门威廉斯人8040-首页 限高架 版权所有

    网站优化技术支撑:济南网站优化

    澳门威尼娱人网站|澳门威廉斯人8040

    XML 地图 | Sitemap 地图